APPLICATION OF PINEAPPLE WASTE FOR BIOETHANOL PRODUCTION AS A CLEAN ENERGY SOURCE FOR PETROL-POWERED ENGINE

Authors

Keywords:

Pineapple waste, Acid hydrolysis, Bioethanol production, Glucose consumption

Abstract

Bioethanol derived from agricultural waste offers a sustainable alternative to conventional energy source such as fossil fuels as the demand for energy continues to increase and the supply depletes. In Malaysia, agricultural wastes are potential to be one of the feedstock for producing bioethanol due to low cost and readily available. The utilization of agricultural waste for bioethanol production also does not disturb the consumer food supply as it is based on waste-to-energy concept. Bioethanol produced is then blended with gasoline (petrol) to create a mixture that can be used in modern vehicles. In this study, pineapple waste has been chosen to investigate the feasibility of using pineapple waste as a substrate to produce bioethanol. Different parts of pineapple waste were treated with different acid concentrations (5, 10 and 15 %, v/v) at a constant high temperature and pressure which were later fermented for a time period of 48 hours. At the same time, one small-scale bioreactor was also fabricated to perform the fermentation of pineapple waste. It was found that the pineapple residue contained a good amount of glucose up to 455.84 g/L when 15% (v/v) H2SO4 used for acid hydrolysis was carried out. However, the fermentation of pineapple pulp had produced the highest bioethanol concentration (375.43 g/L) when 15% (v/v) H2SO4used for acid hydrolysis was performed. Bioethanol concentration obtained through the fabrication of small-scale reactor on the other hand was 374.78 g/L

 

Dimensions

Akin-Osanaiye, B C, H C Nzelibe, and A S Agbaji. (2002). African Journal of Biotechnology. African Journal of Biotechnology. Vol. 4. Academic Journals.

Bello, Roger Hoel, Poliana Linzmeyer, Cláudia Maria Bueno Franco, Ozair Souza, Noeli Sellin, Sandra Helena Westrupp Medeiros, and Cintia Marangoni. (2014). “Pervaporation of Ethanol Produced from Banana Waste.” Waste Management 34 (8):1501–9. https://doi.org/10.1016/j.wasman.2014.04.013.

Dung, Thi Ngoc Bao, Biswarup Sen, Chin-Chao Chen, Gopalakrishnan Kumar, and Chiu-Yue Lin. (2014). “Food Waste to Bioenergy via Anaerobic Processes.” Energy

Procedia 61:307–12. https://doi.org/10.1016/j.egypro.2014.11.1113.

Fish, Wayne W, Benny D Bruton, and Vincent M Russo. n.d. “Biotechnology for Biofuels Watermelon Juice: A Promising Feedstock Supplement, Diluent, and Nitrogen Supplement for Ethanol Biofuel Production.” https://doi.org/10.1186/1754-6834-2-18.

Gabhane, Jagdish, S.P.M. Prince William, Abhijit Gadhe, Ritika Rath, Atul Narayan Vaidya, and Satish Wate. (2014). “Pretreatment of Banana Agricultural Waste for Bio-Ethanol Production: Individual and Interactive Effects of Acid and Alkali Pretreatments with Autoclaving, Microwave Heating and Ultrasonication.” Waste Management 34 (2):498–503. https://doi.org/10.1016/j.wasman.2013.10.013.

Goldemberg, José. (2007). “Ethanol for a Sustainable Energy Future.” Science (New York, N.Y.) 315 (5813):808–10. https://doi.org/10.1126/science.1137013.

Graf, Angela, and Tom Koehler. (2000). “OREGON CELLULOSE-ETHANOL STUDY An Evaluation of the Potential for Ethanol Production in Oregon Using Cellulose-

Based Feedstocks.”

Hossain, A B M S, and A R Fazliny. (2010). “Creation of Alternative Energy by Bio-Ethanol Production from Pineapple Waste and the Usage of Its Properties for Engine.” African Journal of Microbiology Research 4 (9):813–19.

Oberoi, Harinder Singh, Praveen V. Vadlani, Lavudi Saida, Sunil Bansal, and Joshua D. Hughes. (2011). “Ethanol Production from Banana Peels Using Statistically Optimized Simultaneous Saccharification and Fermentation Process.” Waste Management 31 (7):1576–84. https://doi.org/10.1016/j.wasman.2011.02.007.

Obire, O., and E. C. Anyanwu. (2009). “Impact of Various Concentrations of Crude Oil on Fungal Populations of Soil.” International Journal of Environmental Science & Technology 6 (2). Springer-Verlag:211–18. https://doi.org/10.1007/BF03327624.

Papong, Seksan, and Pomthong Malakul. (2010). “Life-Cycle Energy and Environmental Analysis of Bioethanol Production from Cassava in Thailand.” Bioresource

Technology 101 (1). Elsevier:S112–18. https://doi.org/10.1016/J.BIORTECH.2009.09.006.

Sathesh-Prabu, C., and A.G. Murugesan. (2011). “Potential Utilization of Sorghum Field Waste for Fuel Ethanol Production Employing Pachysolen Tannophilus and

Saccharomyces Cerevisiae.” Bioresource Technology 102(3):2788–92. https://doi.org/10.1016/j.biortech.2010.11.097.

Sun, Ye, and Jiayang Cheng. (2002). “Hydrolysis of Lignocellulosic Materials for Ethanol Production: A Review.” Bioresource Technology 83 (1):1–11. https://doi.org/10.1016/S0960-8524(01)00212-7.

Velásquez-Arredondo, H.I., A.A. Ruiz-Colorado, and S. De Oliveira. (2010). “Ethanol Production Process from Banana Fruit and Its Lignocellulosic Residues: Energy Analysis.” Energy 35 (7).Pergamon:3081–87. https://doi.org/10.1016/J.ENERGY.2010.03.052.

Wu, Ken-Jer, Ganesh D. Saratale, Yung-Chung Lo, Wen- Ming Chen, Ze-Jing Tseng, Ming-Ching Chang, Ben-Ching Tsai, Ay Su, and Jo-Shu Chang. (2008). “Simultaneous Production of 2,3-Butanediol, Ethanol and Hydrogen with a Klebsiella Sp. Strain Isolated from Sewage Sludge.” Bioresource Technology 99 (17). Elsevier:7966–70. https://doi.org/10.1016/J.BIORTECH.2008.03.062.

Zhang, Cunsheng, Haijia Su, Jan Baeyens, and Tianwei Tan. (2014). “Reviewing the Anaerobic Digestion of Food Waste for Biogas Production.” Renewable and Sustainable Energy Reviews 38:383–92. https://doi.org/10.1016/j.rser.2014.05.038.

Published

18-03-2023

How to Cite

APPLICATION OF PINEAPPLE WASTE FOR BIOETHANOL PRODUCTION AS A CLEAN ENERGY SOURCE FOR PETROL-POWERED ENGINE. (2023). FUDMA JOURNAL OF SCIENCES, 2(3), 73-78. http://www.fjsadmin.fudutsinma.edu.ng/index.php/fjs/article/view/1387

Issue

Vol. 2 No. 3 (2018): FUDMA Journal of Sciences - Vol. 2 No. 3

Section

Research Articles
Copyright & Licensing

FUDMA Journal of Sciences

How to Cite

APPLICATION OF PINEAPPLE WASTE FOR BIOETHANOL PRODUCTION AS A CLEAN ENERGY SOURCE FOR PETROL-POWERED ENGINE. (2023). FUDMA JOURNAL OF SCIENCES, 2(3), 73-78. http://www.fjsadmin.fudutsinma.edu.ng/index.php/fjs/article/view/1387

Most read articles by the same author(s)